Fig. 1 shows the production process of BDO tar [7]. ... Some chemical wastes mix into coalwaterslurry (CWS) in a proportion known as wastecoalwaterslurry (WCWS), which can control waste releases and recycle valuable resources. With the development of the gasification technology of CWS, the adaptability of raw materials is continually ...
Chu et al. [21] studied the mechanism of modified sludgecoal water slurry (MSCWS) and significantly improved the fluidity and stability of the slurry. Zhang et al. [22] used a coal chemical sludge as raw material and mixed it with lignite, coking coal and lean coal to prepare SCWS; it was shown that the addition of appropriate proportion of ...
Coal water slurry product was more competitive or cheaper than MFO in terms of fuel cost in power plants. Fuel cost of coal water slurry product was USD million/year, and MFO was USD million/year. Based on the result of the study above, the coal water slurry process is feasible to be implemented with adequate infrastructure support
Coalwater slurry fuel is a fuel that is domestic, in large supply, can be handled like a liquid, burns like coal, costs like coal, and has the potential as a near term alternative to No. 6 fuel oil. Unlike the coal gasification and liquefication processes, the capital investment required is modest. While those synthetic fuel processes cost in ...
The production of coalwater slurry fuel involves the crushing of coal or coal sludge to particles between 10 and 65 micrometers diameter (standard crushers can be used); wet milling and homogenisation (with additives as required). The resulting product ( coal slurry) is then prepared for intermediate storage or transport.
The flow chart of pilot platform for refined coal production Particlesize distribution of JDCS and JDRC used for slurry preparation SEM images of coal particles: (a) JDCS, (b) JDRC and (1) at ...
Coal water slurry (CWS) is an important cleancoalbased liquid fuel with the characteristics of highefficiency and lowpollution. This paper aims to implement the principles of clean production and prepare CWS by coblending coal particles and polyethylene terephthalate (PET) microplastics.
It was found that activation energy of conversion is E = 103 kJ/mol and the preexponential factor is A0 = × 10 s 1. It was revealed that coal gasification in SCW without oxidants is the weakly endothermic process. The addition of CO 2 into SCW decreases the conversion rate and increases the CO yield.
The EGas process uses a coalwater slurry feed into an upflow, entrained flow gasifier ... This chapter presents studies on oxidized coal for the production of coalwater slurry. In a study described in the chapter, about 10 g of a lowrank bituminous coal was refluxed with 200 ml of 3(N)HNO 3 for 5 h. The treated coal was cooled ...
The headloss characteristics of the fine (<53 μm) particulate coal water slurry are presented in Fig. 13. The headloss characteristics of the fine particulate coal water slurry is also compared with those of normal tap water. The headloss of the water is found to increase with increase in the flow velocity from to m/s.
An experimental study of the ignition and combustion processes of coalwater slurry (CWS) droplets based on coal enrichment waste in a hightemperature oxidizer at 650850 °C with a syngas addition was carried out. The fuel slurry was a mixture of finely dispersed solid combustible particles (coal sludge, 10100 µm in size) and water. The syngas was a product of biomass pyrolysis and two ...
Coalwater slurry or coalwater mixture (CWS or CWM) is a complex solidliquid dispersion. Several research works have been done concerning the production and use of CWSs being developed worldwide in several different governmental, industrial and academic facilities. In the present paper, studies on the developments achieved in the past three decades with regard to the field mentioned ...
Dispersants, serving as an essential raw material in the formulation of coal water slurry, offer an economical and convenient solution for enhancing slurry concentration, thus stimulating significant interest in the development of novel and efficient dispersants. This paper intends to illuminate the evolution of dispersants by examining both the traditional and the newly conceived types and ...
Coalwaterslurry preheating technology offers another opportunity to boost energy efficiency during gasification, ... Aspen Plus is used to model the chemical production process, and GT Pro is used to model the power generation process. In Section 4, the distribution of exergy loss in the system is mapped, and the impacts of different ...
A Novel ChemicalElectrochemical Hydrogen Production from Coal Slurry by a TwoStep Process: Oxidation of Coal by Ferric Ions and Electroreduction of Hydrogen Ions. ACS Omega 2022, 7 (9) ... The intensification technologies to water electrolysis for hydrogen production A review. Renewable and Sustainable Energy Reviews 2014, 29, 573588.
A total of eight types of organic wastewater were used in the study. Gas washing water (A), sulfur water (B), carbonized water (C) and slag discharge water (D) were the coal gasification wastewater produced by the entrained bed process; Yima wastewater (F) was coal gasification wastewater produced by the crushed coal fixed bed process (Lurgi furnace); coking wastewater (E) was produced by the ...
Municipal sludge (MS) is used to prepare coal water slurry (CWS). This practice is beneficial for resource utilization and reduces treatment costs and environmental pollution. In this study, alkalimodified municipal sludge (AMS) was prepared with Ca(OH)2 as modifier and mixed with coal to produce AMSCWS. The effect and mechanism of MS and AMS on slurry ability, stability, and combustion ...
The average size of fuel droplets in the jet decreases by 512% in comparison with twocomponent coalwater fuel. Ignition delay time of a single droplet of slurry at oxidizer temperature 1273 K increases by 23% in comparison with twocomponent coalwater fuel when 10% of coal is replaced by liquid pyrolysis products.
The temperature in the reactor was varied in the range of °C. An analysis of the composition of the gas obtained during the gasification of three fuels showed that the coalwaterslurry (40 wt% coal, 60 wt% water) was characterized by the maximum yield of H 2 ( vol%) and the minimum share of CO 2 ( vol%). The largest ...
Results showed that coaloilfield wastewaterslurry and coal water slurry both exhibited a similar gasification process. However, compared with coal water slurry, all the gasification ...
Coal water slurry (CWS)[6], [7] refers to a suspended dispersion system containing coal, water and a small amount of additives. Because of its fluidity, CWS is easy to transport by pipeline. However, the preparation of CWS need to consume a large quantity of water, which leads to the waste of water resources.
© DZCrusher - كل الحقوق محفوظة
